Differences
This shows you the differences between two versions of the page.
| Both sides previous revision Previous revision Next revision | Previous revision Next revision Both sides next revision | ||
|
techtalk:ih:carb01g [2019/09/13 00:26] hippysmack [Tickler] |
techtalk:ih:carb01g [2019/09/14 21:07] hippysmack [IH: Carburetor, Intake Manifold & Exhaust Systems - Sub-01g] |
||
|---|---|---|---|
| Line 1: | Line 1: | ||
| [[:techtalk:menu|{{ :techtalk:gototechnicalmenu.jpg|}}]] | [[:techtalk:menu|{{ :techtalk:gototechnicalmenu.jpg|}}]] | ||
| - | ====== IH: Carburetor, Intake Manifold & Exhaust Systems - Sub-01g ====== | + | ====== IH: Carburetor, Intake Manifold & Exhaust Systems - Sub-01G ====== |
| \\ | \\ | ||
| ====== Tillotson Carb Functions, Adjustments, Tuning ====== | ====== Tillotson Carb Functions, Adjustments, Tuning ====== | ||
| ===== Tickler ===== | ===== Tickler ===== | ||
| + | A tickler is any device that is inserted into the bottom hole to 'massage' a little extra gas from the diaphragm. \\ | ||
| + | With the advent off Ethanol, fuel seems to evaporate faster. ((Monte03 of the XLFORUM http://xlforum.net/forums/showthread.php?t=1191289&page=6)) \\ | ||
| + | By 'tickling' the diaphragm via paperclip or spring type pin, you are allowing fuel to enter the accelerator galley via gravity. \\ | ||
| + | Now when you twist the throttle you will get a clean shot of fuel into the intake. \\ | ||
| + | |||
| The Tillotson carburetor runs great, once started. \\ But even with electric start, when cold, it sometimes takes quite a bit of cranking to get it going. ((rgmax of the XLFORUM http://xlforum.net/forums/showthread.php?t=1191289&page=5)) \\ | The Tillotson carburetor runs great, once started. \\ But even with electric start, when cold, it sometimes takes quite a bit of cranking to get it going. ((rgmax of the XLFORUM http://xlforum.net/forums/showthread.php?t=1191289&page=5)) \\ | ||
| Sometimes sometimes twenty kicks later, no start. When warm it sometimes takes 3-4 seconds of cranking to start which still seemed too long. \\ | Sometimes sometimes twenty kicks later, no start. When warm it sometimes takes 3-4 seconds of cranking to start which still seemed too long. \\ | ||
| Line 21: | Line 26: | ||
| Using the paperclip method can be cumbersome with the fuel line, original air cleaner, circuit breaker and tach cable in the way. \\ | Using the paperclip method can be cumbersome with the fuel line, original air cleaner, circuit breaker and tach cable in the way. \\ | ||
| - | A tickler is any device that is inserted into the bottom hole to 'massage' a little extra gas from the diaphragm. \\ | ||
| This was made by S&D installed on a HD2D model. \\ | This was made by S&D installed on a HD2D model. \\ | ||
| {{:techtalk:ih:carb:tillotson_hd2d_pic_3_by_16ouncepbr.jpg?direct&300|}} ((photo by 16ouncePBR of the XLFORUM http://xlforum.net/forums/showthread.php?t=1191289)) {{:techtalk:ih:carb:tillotson_hd2d_pic_4_by_16ouncepbr.jpg?direct&300|}} ((photo by 16ouncePBR of the XLFORUM http://xlforum.net/forums/showthread.php?t=1191289)) \\ | {{:techtalk:ih:carb:tillotson_hd2d_pic_3_by_16ouncepbr.jpg?direct&300|}} ((photo by 16ouncePBR of the XLFORUM http://xlforum.net/forums/showthread.php?t=1191289)) {{:techtalk:ih:carb:tillotson_hd2d_pic_4_by_16ouncepbr.jpg?direct&300|}} ((photo by 16ouncePBR of the XLFORUM http://xlforum.net/forums/showthread.php?t=1191289)) \\ | ||
