Differences
This shows you the differences between two versions of the page.
Both sides previous revision Previous revision | |||
techtalk:ih:oil04a [2021/03/02 18:42] hippysmack removed |
— (current) | ||
---|---|---|---|
Line 1: | Line 1: | ||
- | [[:techtalk:menu|{{ :techtalk:gototechnicalmenu.jpg|}}]] | ||
- | ====== IH: Oiling & Lubrication - Sub-04A ====== | ||
- | ====== Rebuilding the Kidney Tank Oil Cap ====== | ||
- | These pics show how the oil cap comes apart. \\ | ||
- | Here is what you have when you flip it over and clean it up. \\ | ||
- | With the C-clip removed, hold the round end that the dipstick comes out of. \\ | ||
- | Turn the wing nut counter clockwise to unscrew it from the rest of the assembly. \\ | ||
- | The lower section will slide to the side and then lift out one side at a time. \\ | ||
- | This is not necessary to replace the gasket or the O-ring but it may be for something more in depth. \\ | ||
- | |||
- | |Right against the cap you have a C-clip. Pull it out.| Unscrew the dipstick from the cap. || | ||
- | |{{:techtalk:ih:oil:rebuilding_the_kidney_tank_oil_cap_1_by_shameless.jpg?direct&300|}}|{{:techtalk:ih:oil:rebuilding_the_kidney_tank_oil_cap_2_by_shameless.jpg?direct&300|}}|{{:techtalk:ih:oil:rebuilding_the_kidney_tank_oil_cap_3_by_shameless.jpg?direct&300|}}| | ||
- | |||
- | There is an O-ring at the top of the shaft between the cap and the wing nut. \\ | ||
- | If it's flattened, it may cause an oil leak on the top of my tank. \\ | ||
- | |||
- | |Check the O-ring.|This one was replaced with one from an Evo head rebuild (bigger O-ring). \\ The inside diameter was a little big but it fit inside the groove and was thick enough to seat against the cap.|| | ||
- | |{{:techtalk:ih:oil:rebuilding_the_kidney_tank_oil_cap_4_by_shameless.jpg?direct&300|}}|{{:techtalk:ih:oil:rebuilding_the_kidney_tank_oil_cap_5_by_shameless.jpg?direct&300|}}|{{:techtalk:ih:oil:rebuilding_the_kidney_tank_oil_cap_6_by_shameless.jpg?direct&300|}}| | ||
- | |||
- | |||
- | |||
- | \\ | ||
- | |||
- | |||
- | [[:techtalk:menu|{{:techtalk:gototechnicalmenu.jpg|}}]] |