Differences
This shows you the differences between two versions of the page.
Both sides previous revision Previous revision Next revision | Previous revision Last revision Both sides next revision | ||
techtalk:ref:oil05a [2019/06/12 18:20] hippysmack [High Pressure Oil Bypass] |
techtalk:ref:oil05a [2021/04/07 20:06] hippysmack |
||
---|---|---|---|
Line 2: | Line 2: | ||
====== REF: Oiling & Lubrication - Sub-05A ====== | ====== REF: Oiling & Lubrication - Sub-05A ====== | ||
====== High Pressure Oil Bypass ====== | ====== High Pressure Oil Bypass ====== | ||
+ | **This is a Race Only Mod - Install this mod at your own risk!**. \\ | ||
+ | This mod can also be installed on motors with EXTREME wetsumping issues. \\ | ||
+ | Generally speaking, if a street motor wet sumps bad enough to NEED this mod, there are many more items to check off that might need attention instead. \\ | ||
+ | \\ | ||
+ | |||
**Theory behind installing a high pressure bypass**: \\ | **Theory behind installing a high pressure bypass**: \\ | ||
The supply side of the oil pump is over supplying oil to the crank case during sustained high RPM running. \\ | The supply side of the oil pump is over supplying oil to the crank case during sustained high RPM running. \\ | ||
Line 17: | Line 22: | ||
If the pressure gets high enough, the regulator opens and bleeds off some of the pressurized oil, dropping it into the cam box. \\ | If the pressure gets high enough, the regulator opens and bleeds off some of the pressurized oil, dropping it into the cam box. \\ | ||
Then it eventually drains down to the crankcase and gets pumped back to the tank. \\ | Then it eventually drains down to the crankcase and gets pumped back to the tank. \\ | ||
- | They did away with this on 5-speed XL's though. \\ | + | They did away with the pressure regulator on 92 and up 5-speed XL's though. \\ |
Evo Big Twins have a spring loaded bleed-off regulator, as do Twinkies, XR1200's, and 08-up Buells. \\ | Evo Big Twins have a spring loaded bleed-off regulator, as do Twinkies, XR1200's, and 08-up Buells. \\ | ||
Line 228: | Line 233: | ||
Later, a cam chest breather mod was discovered by Deimus of the XLFORUM that was deemed a fix for better crankcase venting. \\ | Later, a cam chest breather mod was discovered by Deimus of the XLFORUM that was deemed a fix for better crankcase venting. \\ | ||
That mod did reduce crankcase pressure allowing for lower engine temps. | That mod did reduce crankcase pressure allowing for lower engine temps. | ||
- | You can read about it here in the Sportsterpedia: [[techtalk:ref:oil05d|Installing the Ultimate Crankcase Vent]]. \\ | + | You can read about it here in the Sportsterpedia: [[techtalk:ref:engmech05d|Installing the Ultimate Crankcase Vent]]. \\ |
**Coincidence**? \\ | **Coincidence**? \\ |