This is an old revision of the document!


IH: Oiling & Lubrication - Sub-03A

77-85 Oil Pump Pics and Approximate Dims

77-85 Oil Pump Pics

Oil Pump Cover

Oil Pump Body

Gear Shaft

Gear Shaft Retaining Ring

Gear Shaft Pins

Check Valve

Brand:
Circle Seal
Manufacturer Part Number: P106-376
Patent #3626977

Gerotors

Feed Gerotors

77-E83 Chamfered Feed Gerotors
(can also be used on L83-85 oil pumps). 1)

Return (scavenge) Gerotors

77-E83 Chamfered Return Gerotors
(can also be used on L83-85 oil pumps). 2)

Separator Plates

Inner Plate

Outer Plate

Outer Separator Plate Seal

Seal 1

Seal 2

Spring Washer

77-85 Oil Pump (Approximate) Dims

Oil Pump Cover Dims

Oil Pump Body Dims

Gear Shaft Dims

Gear Shaft Bushing Dims

Gear Shaft Retaining Ring Dims

Gear Shaft Pin Dims

Check Valve Dims

Brand:
Circle Seal
Manufacturer Part Number: P106-376
Patent #3626977

A small rod was inserted into the check valve to measure the plunger travel which is app. .0845“

App. .002” difference in diameter was noticed between the top and bottom of the hole in the check valve.

Gerotor Dims

Feed Gerotors

77-E83 Chamfered Feed Gerotors
Each gerotor set has an inner and an outer piece and both of these should measure the same in thickness. 3)
(Ea second pic below):

Maximum wear limit between the inner and outer gerotor set is .004“ 4)

This is the most common way to measure how high the feed gerotor sits above the rim of the cover (as in the FSM). 5)
Generally, the straightedge is stood straight up and a feeler gauge is inserted between the straightedge and the cover.
However, if the straightedge is not flat on the bottom edge, it will allow the leading edge of an oversized feeler to partially get in it which may lead to a false reading.

A dial depth gauge is a little more tedious.
First, set the gauge on the gerotor top,
Zero the gauge once you're sure it is flat and square
Then move the gauge so the depth rod falls on the cover area

A depth rod on a caliper is more difficult to use.
You have to rock the base of the caliper square on the gerotor top while holding it tight and drop the rod on the cover.
It's easy to rock it out of square with the gerotor.

Return (scavenge) Gerotors

77-E83 Chamfered Return Gerotors
Each gerotor set has an inner and an outer piece and both of these should measure the same in thickness. 6)
(Ea second pic below):

Maximum wear limit between the inner and outer gerotor set is .004” 7)

Separator Plate Dims

Inner Plate

Outer Plate

Spring Washer Dims


1) , 2)
HD Service Bulletin #M860 dated November 12, 1982 pg 2
3) , 4) , 6) , 7)
70-78 Sportster FSM pg 3-27
5)
70-78 Sportster FSM pg 3-27, 3-28
This website uses cookies. By using the website, you agree with storing cookies on your computer. Also you acknowledge that you have read and understand our Privacy Policy. If you do not agree leave the website.More information about cookies